Download Report

KOLBELCO EDTI COMPRESSORS - 301 N. Smith Ave., Corona, CA 92880-1742 USA
MATERIAL SAFETY DATA SHEET
El- 4600 (All Viscosity Grades)
Emergency Number: 951-279-9400
Kobelco EDTI Compressors
301 N. Smith Ave
Corona, CA 92880-1742 USA.
951 739 3022
Phone:
Date prepared:
951-279-9400
06/07
Chemical Name
CAS REGNO.
PERCENTAGE(%)
1-decene, homopolymer, hydrogenated
68037-01-4
>95%
Mixture
Proprietary Additives
Common Names:
<5%
Synthetic Hydrocarbon Oil (Polyalphaolefin) lubricant
EL-4600-15, EL-4600-22, EL-4600-32,EL-4600-46, EL-4600-68, EL-4600-100,
EL-4600-150, EL-4600-220, EL-4600-320, EL-4600-460
This product is non-hazardous. This product contains no known carcinogens. No special warning labels are required under
OSHA 29 CFR 1910.1200. There are no known chronic effects associated with this materiaL
Eye:
No significant health hazards identified. Temporary mild irritation.
Inhalation :
Product is not toxic by inhalation. Inhalation of mists may result in irritation.
Ingestion:
No significant healtli hazards identified .. Ingestion oflarge amounts will result in diarrhea ..
Skin:
No significant health hazards identified. Possible slight, temporary irritation.
Eye:
Flush eyes with water for 15 minutes. If irritation develops, get medical attention.
Skin:
Wash with soap and water. Remove and launder contaminated clothing before reuse.
develops get medical attention.
Inhalation :
If oil mist is inhaled, remove to fresh air and consult physician. Aid in breathing, if necessary.
Ingestion:
Do NOT induce vomiting unless directed to do so by medical personneL Never give anything by mouth
to an unconscious person .If large quantities ofthis material are swallowed, get immediate medical
attention. (call a physician immediately).
Page I of5
If irritation
KOLBELCO EDTI COMPRESSORS - 301 N. Smith Ave., Corona, CA 92880-1742 USA
Flash Point oc eF) ASTM D93
LOWER EXPLOSIVE LIMIT
(all grades)
Not Established
EL-4600-15
204 (400)
EL-4600-22
204 (400)
Extinguishing Agents:
Water spray/fog, dry chemical, C02 foam.
EL-4600-32
218 (424)
Protective Clothing :
EL-4600-46
246 (475)
Gloves (recommended); goggles; and mechanical
exhaust.
EL-4600-68
260 (500)
Unusual Explosive Hazards:
None
EL-4600-l 00
260 (500)
Fire-fighting Procedures :
EL-4600-150
260 (500)
EL-4600-220
260 (500)
EL-4600-320
260 (500)
EL-4600-460
260 (500)
Burning fluid may evolve irritating/noxious fumes.
Should use NIOSHIMNSA approved self-contained
breathing apparatus. Use water carefully to avoid
violent production of steam. DO NOT spray water
directly on fire. May cause frothing or splashing of
hot material. Products of Combustion: carbon
oxides (CO, C02)
Personal Protection :
Wear suitable protective equipment, especially goggles. Stop source of spill. Dike spill area. Use
absorbent materials to soak up fluid (i.e. sand, sawdust, and commercially available materials.) Wash
spill area with large amounts of water. Properly dispose of all materials.
Procedures:
CAUTION: Keep spills and cleaning runoff out of municipal sewers and open bodies of water.
No special requirements needed.
Keep container tightly sealed when not in use. Keep container in a cool, well-ventilated area.
Keep away from oxidizing materials.
"Empty" containers retain residue (liquid and/or vapor) and can be dangerous. DO NOT PRESSURIZE, CUT, WELD, BRAZE,
SOLDER, DRILL, GRIND OR EXPOSE SUCH CONTAINERS TO HEAT, FLAME, SPARKS, STATIC ELECTRICITY, OR OTHER
SOURCES OF IGNITION; THEY MAY EXPLODE AND CAUSE INJURY OR DEATH. Do not attempt to clean since residue is
difficult to remove. "Empty" drums should be completely drained, properly bunged and promptly returned to a drum re-conditioner. All
other containers should be disposed of in an environmentally safe manner and in accordance with governmental regulations. For
work on tanks refer to Occupational Safety and Health Administration regulations. ANSI Z49.1, and other governmental and industrial
references pertaining to cleaning, repairing, welding, or other contemplated operations.
2 of5
KOLBELCO EDTI COMPRESSORS - 301 N. Smith Ave., Corona, CA 92880-1742 USA
Eye
Goggles. also wear a face shield if splashing hazard exists.
Skin
Not required, but recommended, especially for lengthy exposure. Gloves,
coveralls, apron, boots as necessary to minimize contact.
Inhalation
None normally required. Use in well ventilated area
Ventilation
Mechanical Exhaust. Use with adequate ventilation. If ventilation is inadequate,
use certified respirator that will protect against organic vapor.
Explosion Proofing
None Required
Appearance
Clear liquid colorless to light grey
See data sheet for properties for Specific Viscosity Grade
Solubility in Water
Not Soluble
Physical State
Liquid
Flash Point
Odor
Slight (Very little)
Boiling Point
Vapor Pressure
<O.lmmhg @20°C
Vapor Density (Air=l)
Na
Specific Gravity (Water=l)
oc eF)
oc eF)
Pour Point °C (°F)
0.79-0.85
>204 (400)
Not available
-30 (-22) or lower
A void inhalation of vapors and spray mist.
Hazardous Decomposition:
Hazardous Polymerization:
Analogous compounds evolve carbon monoxide, carbon dioxide, and other Carbon Oxides.
Will not occur.
3 of5
KOLBELCO EDTI COMPRESSORS - 301 N. Smith Ave., Corona, CA 92880-1742 USA
To the best of our knowledge, the toxicological properties of this material have not been fully investigated. By analogy to similar
compounds, this product is likely to be a mild skin irritant, while essentially non-toxic.
Chronic Toxicity
CARCINOGENIC EFFECTS: No component of this product at levels greater than 0.1% is
identified as acarcinogen by ACGIH or the International Agency for Research on Cancer
(IARC). No component of this productpresent at levels greater than 0.1% is identified as a
carcinogen by the U.S. National Toxicology Program (NTP)or the U.S. Occupational Safety
and Health Act (OSHA).
MUTAGENIC EFFECTS: No component of this product at levels greater than 0.1% is
classified by establishedregulatory criteria as a mutagen.
TERATOGENIC EFFECTS/DEVELOPMENTAL TOXICITY: No component of this
product at levels greater than 0.1% is classified by established regulatory criteria as
teratogenic or embryotoxic.
REPRODUCTION TOXICITY: No component of this product at levels greater than 0.1% is
classified
·ve toxin.
Special Remarks
Contains no carcinogens. Similar compounds essentially non-toxic.
Incinerate this product and all associated wastes in a licensed facility in accordance with Country, and regional regulations.
Degree of Hazard
Health
NFPA
0
HMIS
0
HAZARD RATINGS
0
Fire
Reactivity
Insignificant
Moderate
0
0
4 of5
2
High
KOLBELCO EDTI COMPRESSORS - 301 N. Smith Ave., Corona, CA 92880-1742 USA
This product is non-hazardous. The product contains no known carcinogens. No special warning labels are required under OSHA
29CFR 1910.1200. OSHA hazard warnings are not applicable for this product; therefore no OSHA Warnings would appear on the
label. No EPA hazard classification code.
DOT Classification: Not Regulated
ICAO/IATA Classification
Proper shipping name: Not regulated
lATA Class
UN number: Not regulated.
Packing Group: Not regulated.
Marine Pollutant: Not a Pollutant
Special Provisions for transport: None Identified
ADR/RID Classification
UN number: Not regulated.
Proper shipping name: Not regulated.
ADR/RID Class: Not regulated.
Packing Group: Not regulated.
U.S. Regulations
IMO/IMDG Classification
Proper shipping name: Not regulated
IMDG Class: Not regulated
UN number: Not regulated.
Packing Group: Not regulated.
Marine Pollutant: Not
US INVENTORY (TSCA): Listed on inventory.
SARA Title Ill Section 302 Extremely Hazardous Substances ( 40 CFR Part 355):: This product is not regulated under
Section 302 of SARA and 40 CFR Part 355.
SARA Title Ill Sections 311/312 Hazardous Categorization (40 CFR Part 370):: Defined as non-hazardous by OSHA under 29
CFR 1910.1200(d).
SARA 313 toxic chemical notification and release reporting: No products were found.
CERCLA Sections 102a/103 Hazardous Substances (40 CFR Part 302.4):: This material is not regulated under CERCLA
State Regulations
were found
Other Regulations
AUSTRALIAN INVENTORY (AICS): Listed on inventory.
CANADA INVENTORY (OSL): Listed on inventory.
CHINA INVENTORY (IECS): Listed on inventory.
EC INVENTORY (EINECS/ELINCS): In compliance.
JAPAN INVENTORY (ENCS): Listed on inventory.
KOREA INVENTORY (ECL): Listed on inventory.
PHILIPPINE INVENTORY {PICCS): Listed on inventory
DISCLAIMER OF WARRANTY:
The information contained herein is based upon data available to us and reflects our best professional judgment. However, no
warranty of merchantability, fitness for any use, or any other warranty is expressed or implied regarding the accuracy of such data.
The results to be obtained from the use thereof, or that any such use does not infringe any patent. Since the information contained
herein may be applied to under conditions of use beyond our control and with witch we may be unfamiliar, we do not assume any
responsibility for the results of such application. This information is furnished upon the condition that the person receiving it shall
make his own determination of the suitability of the material for his particular purpose.
5 of5