™™ XPS SERIES Instructions manual
™ ™™ XPS SERIES Instructions manual 2014 XTREME OUTDOOR PRODUCTS 7425 Chavenelle Road Dubuque, IA 52002 Tel: 563-690-1214 ● Fax: 563-582-3680 www.xopoutdoors.com WARNING!!! RESPONSIBILITIESIt is your responsibility to carefully read and understand all instructions and safety warnings/labels, expiration dates, and how to use any XOP merchandise before each use. This instruction manual, enclosed DVD and product labels provide important use and safety information. DO NOT Remove or Obscure any safety warning labels on any XOP merchandise. When hunting from a tree stand falls can occur at any time after leaving the ground, causing injury or death. Please retain this manual, DVD and all product labels for future reference. WARNING!!! You must wear a fall arrest system at all times after leaving the ground. Be sure to read and understand all warnings and instructions and use all safety devices provided. Never exceed the maximum weight load of 350 pounds. Practice installing, adjusting and using products at ground level prior to using in an elevated position. Never use XOP merchandise while taking drugs (even prescription) or alcohol. Never use on a dead, leaning, diseased or loose barked tree or on a utility pole. Never use during inclement weather such as rain, lightning, windstorms or icy conditions. Never jump or bounce on the foot platform or seat platform; or stand on the seat platform. Always pull up equipment after you are fully secured in tree stand. DO NOT modify product in any way. This includes repairing, replacing parts, or altering, adding or attaching anything to it, except as explicitly authorized in writing by the manufacturer. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 1 TABLE OF CONTENTS Tree Stand Safety Guidelines............................................................3 Xtreme Outdoor Products Full Body Harness..................................6 Tether Rope............................................................................8 Suspension Relief Device......................................................9 Climbing Rope.......................................................................10 Xtreme Outdoor Products XPS Hang On Stands.............................11 Medium & Large Hang On Stands Xtreme Outdoor Product Climbing Stands.....................................15 Strike Force, Enforcer and Punisher Climbing Stands Xtreme Outdoor Products Climbing Sticks...................................25 Long Stick-32”, Short Stick-17” Xtreme Outdoor Products Packing Straps...................................28 Medium & Large Hang On Stands Strike Force, Enforcer and Punisher Climbing Stands ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 2 TREE STAND SAFETY GUIDELINES ALWAYS wear a Fall Arrest System (FAS)/Full Body Harness meeting TMA Standards even during ascent and descent. Be aware that single strap belts and chest harnesses are no longer allowed Fall Arrest devices and should not be used. Failure to use a FAS could result in serious injury or death. ALWAYS read and understand the manufacturer’s WARNINGS & INSTRUCTIONS before using the tree stand each season. Practice with the tree stand at ground level prior to using at elevated positions. Maintain the WARNINGS & INSTRUCTIONS for later review as needed, for instructions on usage to anyone borrowing your stand, or to pass on when selling the tree stand. Use all safety devices provided with your tree stand. NEVER exceed the weight limit specified by the manufacturer. If you have any questions after reviewing the WARNINGS & INSTRUCTIONS, please contact the manufacturer. ALWAYS inspect the tree stand and the Fall Arrest System for signs of wear or damage before each use. Contact only the manufacturer for replacement parts. Destroy all products that cannot be repaired by the manufacturer and/or exceed recommended expiration date, or if the manufacturer no longer exists. The FAS should be discarded and replaced after a fall has occurred. ALWAYS practice in your Fall Arrest System in the presence of a responsible adult prior to using it in an elevated hunting environment; learning what it feels like to hang suspended in it at ground level and how to properly use your suspension relief device. ALWAYS attach your Fall Arrest System in the manner and method described by the manufacturer. Failure to do so may result in suspension without the ability to recover into your tree stand. Be aware of the hazards associated with the Fall Arrest System and the fact that prolonged suspension in a harness may be fatal. Have in place a plan for rescue, including the use of cell phones or signal devices that may be easily reached and used while suspended. If rescue personnel cannot be notified, you must have a plan for recovery/escape. If you have to hang suspended for a period of time before help arrives, exercise your legs by pushing against the tree or doing any other form of continuous motion or use your suspension relief device. Failure to recover in a timely manner could result in serious injury or death. If you do not have the ability to recover/escape, hunt from the ground. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 3 TREE STAND SAFETY GUIDELINES ALWAYS hunt with a plan and, if possible, a buddy. Before you leave home let others know your exact hunting location, when you plan to return and who is with you. ALWAYS carry emergency signal devices such as a cell phone, walkie-talkie, whistle, signal flare, personal locating device and flashlight on you at all times and within reach even while you are suspended in your Fall Arrest System. Watch for changing weather conditions. In the event of an accident, remain calm and seek immediate help. ALWAYS select the proper tree for use with your tree stand. Select a live, straight tree that fits within the size limitations recommended in your tree stand’s instructions. Do not climb or place a tree stand against a leaning tree. Never leave a tree stand installed for more than two weeks since damage could result from changing weather conditions and/or from other factors not obvious with a visual inspection. ALWAYS use a haul line to pull up your gear, unloaded firearm or bow to your tree stand once you have reached your desired hunting height. Never climb with anything in your hands or on your back. Prior to descending, lower your equipment on the opposite side of the tree. ALWAYS know your physical limitations. Do not take chances. Do not climb when using drugs, alcohol or if you are sick or tired. If you start thinking about how high you are, do not go any further. NEVER use homemade or permanently elevated stands or made modifications to a purchased tree stand without the manufacturer’s written permission. Only purchase and use tree stand and Fall Arrest Systems meeting or exceeding TMA standards. For a detailed list of certified products, contact the TMA office or refer to the TMA website at http://www.tmastands.com NEVER hurry!! When climbing with a tree stand, make slow, even movements of no more than ten to twelve inches at a time. Make sure you have proper contact with the tree and/or tree stand every time you move. On ladder-type tree stands, maintain three points of contact with each step. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 4 GENERAL Maintenance Be sure to check all nuts, bolts, pins, cables and straps before each use. Nuts are to be secure and tight. Cables and Straps should not show any signs of wear. Replace all worn and/or damaged parts with components from Xtreme Outdoor Products only. Traction climbing belt (This applies to the Strike Force, Enforcer & Punisher Climbing Stands) 1. 2. 3. Before using, with a permanent marker, write the date of first use on each belt. Carefully inspect each belt before each use. Replace belts every five (5) years or when you see any signs of the following: a. Belt has any visible external cracks or tears. b. Belt has any internal cables broken. c. Belt has any “teeth” that are torn, cut or missing, or offset from their normal pitch. Pictured below is the proper use of the Traction Climbing Belt for the Xtreme Outdoor Products Climbers (Fig 1). These belts are designed to be used on the XOP climbers only. Always use the traction belts in this position. DO NOT USE the traction belts if they are positioned incorrectly (Fig 2). Improper positioning can cause damage to the belts. WARNING: Each belt is marked with an arrow. This arrow designates the end of the belt. There should be no part of the arrow showing after the locking mechanism is engaged. Failure to follow these instructions may cause belt to disengage and locking mechanism to open. Fig 2 Fig 1 Polyester woven cam belts and Ratchet Straps (This applies to the Medium & Large Hang On Stands) 1. 2. 3. Before using, with a permanent marker, write the date of first use on each belt. Carefully inspect each belt before each use. Replace belts every year or when you see signs of the following: a. Webbing is cut, torn, worn or fraying. b. Buckle is bent, cam release is binding or ratchet does not lock. c. Stitching is loose, cut or unraveling. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 5 Xop FULL BODY HARNESS fall arrest system RESPONSIBILITIESIt is your responsibility to carefully read and understand all instructions and safety warnings/labels, expiration dates, and how to use any XOP merchandise before each use. This instruction manual, enclosed DVD and product labels provide important use and safety information. DO NOT Remove or Obscure any safety warning labels on any XOP merchandise. When hunting from a tree stand falls can occur at any time after leaving the ground, causing injury or death. 1. 2. 3. Inspect Fall Arrest System before each use. Replace Fall Arrest System every two (2) years. Replace Fall Arrest System after arresting a fall or earlier if any part of the product is cut, worn, torn or fraying. WARNING!!! You must wear a fall arrest system at all times after leaving the ground. Be sure to read and understand all warnings and instructions and use all safety devices provided. Never exceed the maximum weight load of 350 pounds. The Fall Arrest System is designed for single person adult use only. Persons under the age of 18 years should not attempt to use this or any XOP merchandise without direct adult supervision. Practice installing, adjusting and using products at ground level prior to using in an elevated position. Never use XOP merchandise while taking drugs (even prescription) or alcohol. Never use on a dead, leaning, diseased or loose barked tree or on a utility pole. Never use during inclement weather such as rain, lightning, windstorms or icy conditions. Never jump or bounce on the foot platform or seat platform; or stand on the seat platform. Always pull up equipment after you are fully secured in tree stand. DO NOT modify product in any way. This includes repairing, replacing parts, or altering, adding or attaching anything to it, except as explicitly authorized in writing by the manufacturer. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 6 Xop fUll BODY HARNESS - FAS Step 1– Place the harness over your shoulders as pictured. Step 2 – Thread the waist belt through the waist buckle making sure that it is snug around your waist. Step 3 – Wrap one leg strap around your leg (from the front to the back) making adjustments so that the hook is even with your waist belt. Place the hook under the waist belt, hooking it securely against the waist strap. Step 4 – Repeat Step 3 with the opposite leg strap. This leg strap should run between your legs and through the loop of the first strap before hooking it securely against the waist strap. Step 5 – When fitted properly this should allow your tether to hang freely in the back. Step 6 – Carefully read, understand and follow the instructions for the TETHER ROPE (page 8), SUSPENSION RELIEF DEVICE (page 9) and CLIMBING ROPE (page 10). NOTE: For all hang on stands, you MUST use the Climbing Rope (page 10) to remain attached to the tree at all times until the tether rope is secured to the tree and harness properly. You must read and understand all instructions for the Climbing Rope and Tether Rope used with the FAS prior to each use before leaving the ground. At NO TIME should you ever be detached from the tree. Practice at ground level prior to each use. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 7 Xop TETHER ROPE Used with the xop fUll BODY HARNESS - fas Make sure you have read and understand all instructions. Practice first at ground level. Do not use while intoxicated or if taking medications that cause drowsiness. Do not attach to rotten, loose bark or dead trees, and metal or utility poles. Avoid using during wet or icy conditions, or during lightning storms. Haul gun or bow up from ground after climbing tree. Do not jump on platform or seat, nor should you stand on seat. Do not attempt to alter any XOP product in any way. The maximum weight load is 350 pounds. Failure to follow all instructions could cause serious injury or death. Inspect before each use. Replace every 2 years or earlier if the rope is cut or worn. Replace after arresting a fall, or earlier if the rope is cut or worn. Step 1 – Locate the small loop and large loop on the rope assembly. The carabineer clip should always be attached to the prusik knot and the small loop of the assembly. Step 2 – Wrap the rope round the tree. Thread the carabineer clip and prusik knot through the large loop making sure you go through the large loop two (2) times. Step 3 – Pull the rope assembly tightly against the tree. Slide the prusik knot tightly up against the tree. Step 4 – Attach the tether strap from the back of the harness onto the carabineer clip of the tether rope. NOTE: When positioning the tether rope, position the rope as high as possible to reduce the distance of falling, if a fall may occur. Always double check to be sure that the tether strap on the FAS is tight to the tether rope when in the seated position. The connection of the tether rope to the tree should be located 90 degrees from the tether strap connection. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 8 Xop suspension relief device Used with the xop fUll BODY HARNESs - FAS ADJUSTING THE SRD LENGTH The Suspension Relief Rope should be adjusted at ground level so that it hangs down and forms a large loop just above your ankle. After adjustment is complete, fold the rope and re-secure with provide band. USING THE SRD DURING A FALL Step 1 – Locate the Suspension Relief Rope attached to the tail end of the harness. Pull to release the rubber band. Step 2 – The SRD will fall down allowing you to place your foot into the loop and stand, relieving pressure. Occasionally exercise each leg by pushing against the strap. Step 3 – Once you have maintained your composure, if possible, attempt to reenter your tree stand or climbing device, if it is safe to do so. If you are unable to do so, use your signaling device to call for help. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 9 Xop CLIMBING ROPE Used with the xop fUll BODY HARNESs - FAS The Suspension Relief Rope will double as the Climbing Rope. NOTE: For Hang On Stands, use the Climbing Rope to remain attached to the tree at all times until the Tether Rope is secured to the tree and harness properly. Read and understand all instructions of the climbing rope and tether rope used with the FAS prior to each use before leaving the ground. At NO TIME should you ever be detached from the tree. Practice at ground level prior to each use. Step 1 – At ground level, remove the Suspension Relief rope from the tail end of the harness. The suspension relief rope now becomes the climbing rope. Step 2 – Place the stitched loop of the climbing rope under the right side of the waist belt of the harness as shown above. Step 3 – Thread the remaining rope through the loop and secure tightly. Step 4 –Wrap the rope around the tree and hook the loop into the locking link attached to the left side of the waist belt of the harness. Twist the locking link closed. Step 5 – Slowly lean backwards, away from tree, to make sure everything is attached securely. Do not climb until you are sure the FAS and climbing belt are attached correctly. CLIMBING WITH CLIMBING ROPE Step 6 – To climb the tree you will need to repeatedly reposition the climbing rope at a higher level during your ascent. To reposition the rope lean towards the tree to take weight off of the climbing rope. WHEN YOU REACH THE DESIRED HEIGHT OF YOUR STAND PLATFORM DO NOT UNHOOK/REMOVE YOUR CLIMBING BELT. Step 7 – Attach the tether rope to the tree and FAS at a level higher than the platform. Make sure the tether rope is not twisted and the tether strap between the tether rope and FAS, DOES NOT wrap around your neck. Once tether rope is securely fastened to tree and FAS, unhook the climbing strap and step down onto platform. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 10 Xop HANG ON STANDS Including the Medium Hang On and Large Hang On RESPONSIBILITIESIt is your responsibility to carefully read and understand all instructions and safety warnings/labels, expiration dates, and how to use any XOP merchandise before each use. This instruction manual, enclosed DVD and product labels provide important use and safety information. DO NOT Remove or Obscure any safety warning labels on any XOP merchandise. When hunting from a tree stand falls can occur at any time after leaving the ground, causing injury or death. 1. 2. 3. Inspect Fall Arrest System before each use. Replace Fall Arrest System every two (2) years. Replace Fall Arrest System after arresting a fall or earlier if any part of the product is cut, worn, torn or fraying. WARNING!!! You must wear a fall arrest system at all times after leaving the ground. Be sure to read and understand all warnings and instructions and use all safety devices provided. Never exceed the maximum weight load of 350 pounds. The Fall Arrest System is designed for single person adult use only. Persons under the age of 18 years should not attempt to use this or any XOP merchandise without direct adult supervision. Practice installing, adjusting and using products at ground level prior to using in an elevated position. Never use XOP merchandise while taking drugs (even prescription) or alcohol. Never use on a dead, leaning, diseased or loose barked tree or on a utility pole. Never use during inclement weather such as rain, lightning, windstorms or icy conditions. Never jump or bounce on the foot platform or seat platform; or stand on the seat platform. Always pull up equipment after you are fully secured in tree stand. DO NOT modify product in any way. This includes repairing, replacing parts, or altering, adding or attaching anything to it, except as explicitly authorized in writing by the manufacturer. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 11 Xop HANG ON STANDS Including the Medium Hang On and Large Hang On Medium (XPS-MHO) Large (XPS-LHO) USING THE OFFSET BRACKET Step 1 – Holding the hang on stand in an open position with the seat up, center the offset bracket against the tree. Loop one end of the gray cam belt around the circular button located on the beam. Wrap the opposite end of the cam around the tree and place its loop over the same circular button. Pull the belt tight. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 12 Xop HANG ON STANDS Including the Medium Hang On and Large Hang On USING THE OFFSET BRACKET (continued) Step 2 – Holding the beam against the tree, lift the foot platform up and pull the gray cam tight again. Be sure there is no slack in the belt. Pushing the back side of the seat platform will help ensure the seat is set. Step 3 – Lower the platform. The additional lower bonus strap can be added at this time. Please see addendum with the instructions. Step 4 – Hold the seat platform with one hand and the tree with the other. Your tree stand should be positioned so that you can step downward from your climbing aids onto the center of the foot platform. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 13 Xop HANG ON STANDS Including the Medium Hang On and Large Hang On USING FOOT PLATFORM LEVELING SYSTEM Pictured above is the foot platform leveling system. To level the platform, loosen the black knobs on each side of the beam. Place the bar in the selected slot for a level platform. Once foot platform is level tighten both knobs. USING THE SEAT PLATFOR M LEVELING SYSTEM Pictured to the right is the seat platform leveling system. To level the platform, adjust the head of the bolt in or out until your desired position is reached. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 14 Xop CLIMBING STANDS Including the Strike Force, Enforcer and Punisher RESPONSIBILITIESIt is your responsibility to carefully read and understand all instructions and safety warnings/labels, expiration dates, and how to use any XOP merchandise before each use. This instruction manual, enclosed DVD and product labels provide important use and safety information. DO NOT Remove or Obscure any safety warning labels on any XOP merchandise. When hunting from a tree stand falls can occur at any time after leaving the ground, causing injury or death. 4. 5. 6. Inspect Fall Arrest System before each use. Replace Fall Arrest System every two (2) years. Replace Fall Arrest System after arresting a fall or earlier if any part of the product is cut, worn, torn or fraying. WARNING!!! You must wear a fall arrest system at all times after leaving the ground. Be sure to read and understand all warnings and instructions and use all safety devices provided. Never exceed the maximum weight load of 350 pounds. The Fall Arrest System is designed for single person adult use only. Persons under the age of 18 years should not attempt to use this or any XOP merchandise without direct adult supervision. Practice installing, adjusting and using products at ground level prior to using in an elevated position. Never use XOP merchandise while taking drugs (even prescription) or alcohol. Never use on a dead, leaning, diseased or loose barked tree or on a utility pole. Never use during inclement weather such as rain, lightning, windstorms or icy conditions. Never jump or bounce on the foot platform or seat platform; or stand on the seat platform. Always pull up equipment after you are fully secured in tree stand. DO NOT modify product in any way. This includes repairing, replacing parts, or altering, adding or attaching anything to it, except as explicitly authorized in writing by the manufacturer. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 15 Xop Climbing STANDS Including the Strike Force, Enforcer and Punisher Strike Force (XPS-C) Enforcer (XPS-SC) Punisher (XPS-WC) Traction climbing belt (This applies to the Strike Force, Enforcer & Punisher Climbing Stands) 7. 8. 9. Before using, with a permanent marker, write the date of first use on each belt. Carefully inspect each belt before each use. Replace belts every five (5) years or when you see any signs of the following: d. Belt has any visible external cracks or tears. e. Belt has any internal cables broken. f. Belt has any “teeth” that are torn, cut or missing, or offset from their normal pitch. Pictured below is the proper use of the Traction Climbing Belt for the Xtreme Outdoor Products Climbers (fig 1). These belts are designed to be used on the XOP climbers only. Always use the traction belts in this position. DO NOT USE the traction belts if they are positioned incorrectly (fig 2). Improper positioning can cause damage to the belts. WARNING: Each belt is marked with an arrow. This arrow designates the end of the belt (fig 3). There should be no part of the arrow showing after the locking mechanism is engaged (fig 4). Failure to follow these instructions may cause belt to disengage and locking mechanism to open. Fig 2 Fig 1 ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 16 Xop climbing STANDS Including the Strike Force, Enforcer and Punisher ATTACHING THE TETHER STRINGS TO THE CAM Step 1 – Run the tether string through the narrow hole at the end of the cam locking mechanism. Step 2 – Tie the ends together. Step 3 – Pull the cord to the end of the slot. ATTACHING THE STABILIZER STRAPS TO THE STANDS Air Strike Step 1 – Wrap the short end of the strap behind the seat casting on the front corner. Air Strike Step 2 – Thread the buckle through the loop and pull tight. Air Strike Step 3 – Wrap the long end of the strap behind the foot casting on the side. Thread the tag end of the strap through the loop and pull tight. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 17 Xop Climbing STANDS Including the Strike Force, Enforcer and Punisher INSTALLING THE CAST FOOT PLATFORM First install the foot of the climber. Step 1 – Loosen the black torque knobs and pull inward on the hinge washers. Step 2 – With your thumbs, push both hinges away from you, towards the end of the slot. Step 3 – Once the hinges are in the upright position, re-tighten the torque knobs. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 18 Xop Climbing STANDS Including the Strike Force, Enforcer and Punisher INSTALLING THE CAST FOOT PLATFORM (Continued) Step 4 – Unlatch the cam and pull the belt out of the square tube. Step 6 – Lock the cam securely. Step 5 – Wrap the traction belt around the tree, adjusting the belt so that the platform is slightly higher on the front end. Insert the belt back into the square tube. NOTE: The point of the arrow marks the end of the belt. No part of the arrow should be showing after the cams are in the locked position. WARNING – Failure to follow these instructions could cause belt to disengage and cam to open. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 19 Xop Climbing STANDS Including the Strike Force, Enforcer and Punisher INSTALLING THE SEAT PLATFORM (Strike Force) Install the seat of the climber second. Step 8A – Wrap the traction belt around the tree. Step 7A – For the hand climber, swivel the square tubes so that they rest on the side of the casting. Step 9A – Insert the belt back into the square tube. Step 10A – Lock the cam securely. NOTE: The point of the arrow marks the end of the belt. No part of the arrow should be showing after the cams are in the locked position. WARNING – Failure to follow these instructions could cause belt to disengage and cam to open. Step 11A – Connect the stabilizer straps. These straps must always remain connected while the stand is in use. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 20 Xop Climbing STANDS Including the Air Strike, Enforcer and Punisher INSTALLING THE SEAT PLATFORM (Enforcer & Punisher) Install the seat of the climber second. Step 8B – Pull inward on the hinge washers. Step 7B – For the sit climbers, Loosen the black torque knobs. Step 10B – Wrap the traction belt around the tree. Step 11B – Insert the belt back into the square tube. Step 9B – With your thumbs, push both hinges away from you, towards the end of the slot. Once the hinges are in the upright position, re-tighten the torque knobs. Step 12B – Insert the belt back into the square tube and lock the cam securely. NOTE: The point of the arrow marks the end of the belt. No part of the arrow should be showing after the cams are in the locked position. WARNING – Failure to follow these instructions could cause belt to disengage and cam to open. Step 13B – Connect the stabilizer straps. These straps must always remain connected while the stand is in use. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 21 Xop Climbing STANDS Including the Strike Force, Enforcer and Punisher CLIMBING INSTRUCTIONS (Strike Force) Step 1 – While wearing your Fall Arrest System, harness yourself to the tree. Step 2 – Grasp the seat platform and support your weight with your arms. Step 3 – Place your feet at an angle under the arm adjustment brackets. Apply light pressure to the hinge with the inside of your foot. Step 4 – With your arms supporting you, bend at the knees to release the foot platform from the tree. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 22 Xop Climbing STANDS Including the Strike Force, Enforcer and Punisher CLIMBING INSTRUCTIONS (Strike Force) Step 5 – Keeping one foot under the bracket, step back on foot platform with the other to secure/set the platform into place. Step 7 – Release the seat platform; raise it to a height you feel comfortable with. Repeat steps 5-7. Step 6 – Slide the harness strap up the tree to the appropriate height. Step 8 – When reaching your desired height and the platform is level, adjust the harness strap height so it is tight when in seated position. While seated, pull stabilizer straps tight. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 23 Xop Climbing STANDS Including the Air Strike, Enforcer and Punisher CLIMBING INSTRUCTIONS (Enforcer and Punisher) Step 1 – While wearing your Fall Arrest System, harness yourself to the tree. Step 2 – Step into the center of the platform. Step 5 – Pull the stand up with your Step 3 – Evenly distribute your Step 4 – Apply light pressure legs. Keeping one foot under the weight on the climber’s sit bar. to the hinge with the inside of bracket, step back on foot platform your foot, bend at the knees Place your feet at an angle with the other to secure/set the to release the foot platform under the arm adjustment platform into place. from the tree. brackets as shown. Step 6 – Slide the harness up the tree to the appropriate height. Release the seat platform; raise it to a height you feel comfortable with. Repeat .steps 2-6. Step 7 – When reaching your desired height and the platform is level, adjust the harness strap height so it is tight when in seated position. While seated, pull stabilizer straps tight. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 24 Xop Climbing STickS Including ALL XOP Climbing Sticks RESPONSIBILITIESIt is your responsibility to carefully read and understand all instructions and safety warnings/labels, expiration dates, and how to use any XOP merchandise before each use. This instruction manual, enclosed DVD and product labels provide important use and safety information. DO NOT Remove or Obscure any safety warning labels on any XOP merchandise. When hunting from a tree stand falls can occur at any time after leaving the ground, causing injury or death. 10. Inspect Fall Arrest System before each use. 11. Replace Fall Arrest System every two (2) years. 12. Replace Fall Arrest System after arresting a fall or earlier if any part of the product is cut, worn, torn or fraying. WARNING!!! You must wear a fall arrest system at all times after leaving the ground. Be sure to read and understand all warnings and instructions and use all safety devices provided. Never exceed the maximum weight load of 350 pounds, except where noted Fall Arrest System is designed for single person adult use only. Persons under the age of 18 years should not attempt to use this or any XOP merchandise without direct adult supervision. Practice installing, adjusting and using products at ground level prior to using in an elevated position. Never use XOP merchandise while taking drugs (even prescription) or alcohol. Never use on a dead, leaning, diseased or loose barked tree or on a utility pole. Never use during inclement weather such as rain, lightning, windstorms or icy conditions. Never jump or bounce on the foot platform or seat platform; or stand on the seat platform. Always pull up equipment after you are fully secured in tree stand. DO NOT modify product in any way. This includes repairing, replacing parts, or altering, adding or attaching anything to it, except as explicitly authorized in writing by the manufacturer. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 25 Xop Climbing STickS Including ALL XOP Climbing Sticks 32” Stick (DX-CS) 17” Stick (DX-SS) ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 26 Xop Climbing STickS Including ALL XOP Climbing Sticks Step 1 – Place the Climbing Stick V-bracket against the center of the tree. With one end of the belt attached to the button, wrap the opposite end around the tree. Place the open loop over the button. Pull tightly on the tag end of the belt to secure it to the tree. Step 3 – Slide the rope assembly up the tree before you proceed to install your next climbing stick. Step 2 – While firmly holding the top 2 steps with each hand, pull down until the climbing stick is firmly attached to the tree. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 27 Xop Back packing instructions BACK PACKING INSTRUCTIONS (Medium & Large Hang On) NOTE: These instructions will allow you to properly install the back packing straps to the cast aluminum platforms . Step 1 – Locate the smooth rib on the casting. This is where you will attach the straps. Step 2 – Go over the top of the bar, keeping the stitching face up. Take the tail end of the strap and run it through and back down again through the buckle. Step 4 – Using the opposite end of the strap, go over the top of the second rib and back through one bar of the buckle and then back through the second bar of the buckle. Step 3 – Locate the other smooth rib. REPEAT STEPS 1-4 ON THE OTHER SIDE. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 28 Xop Back packing instructions BACK PACKING INSTRUCTIONS (Strike Force) Step 1 – Fold the seat & foot platforms flat. Lay the seat section on top of the foot platform with the cushion facing down. Step 3 – Hook the opposite ends of the bungee cord to the foot platform near the gripping teeth as shown. Step 2 – Attach the plastic hook of the bungee cord to the foot platform behind the bow holder. Step 4 – Criss cross the stabilizer straps and secure as shown. Step 5 – With the stand fully connected together, position the stand as shown. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 29 Xop Back packing instructions BACK PACKING INSTRUCTIONS (Enforcer & Punisher) Step 1 – Fold the top and bottom flat with the belts retracted into the tubes as far as possible. Place the top upside down on top of the bottom. Step 2 – Hook the bungee cord as shown above. Loop the opposite ends of the cord to the rungs of the platform. Step 4 – With the stand fully connected together, position the stand as shown. Step 3 – Criss cross the stabilizer straps and secure as shown. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 30 WARNING!!! RESPONSIBILITIESIt is your responsibility to carefully read and understand all instructions and safety warnings/labels, expiration dates, and how to use any XOP merchandise before each use. This instruction manual, enclosed DVD and product labels provide important use and safety information. DO NOT Remove or Obscure any safety warning labels on any XOP merchandise. When hunting from a tree stand falls can occur at any time after leaving the ground, causing injury or death. Please retain this manual, DVD and all product labels for future reference. WARNING!!! You must wear a fall arrest system at all times after leaving the ground. Be sure to read and understand all warnings and instructions and use all safety devices provided. Never exceed the maximum weight load of 350 pounds. Practice installing, adjusting and using products at ground level prior to using in an elevated position. Never use XOP merchandise while taking drugs (even prescription) or alcohol. Never use on a dead, leaning, diseased or loose barked tree or on a utility pole. Never use during inclement weather such as rain, lightning, windstorms or icy conditions. Never jump or bounce on the foot platform or seat platform; or stand on the seat platform. Always pull up equipment after you are fully secured in tree stand. DO NOT modify product in any way. This includes repairing, replacing parts, or altering, adding or attaching anything to it, except as explicitly authorized in writing by the manufacturer. ALWAYS WEAR A CERTIFIED FALL ARREST SYSTEM (FAS) WHILE USING A TREE STAND, CLIMBING STICKS OR ANY OTHER EQUIPMENT THAT YOU CHOOSE TO USE IN AN ELEVATED POSITION OFF OF THE GROUND. Do not leave the ground without your FAS properly fitted and attached as instructed. Failure to follow all instructions could result in serious injury or death. If you have any questions or concerns regarding this instruction manual or the product, please call Customer Service (563) 690-1214 or visit our website (www.xopoutdoors.com) 31
© Copyright 2024