Download Report

MAGIC BRIGHT CHEMICALS, INC.
44 E lndustrial Park Circle
Waldorf, Maryland 20602
Phone: (301) 870-8484
Emergency Phone: (301) 870-8484
lDate Prepared. 2lO1
MATERIAL SAFEry DATA SHEET
TO COMPLYWITH OSHA
may be used to comply with
OSHA's Hazard Communication
Showtime Rubber & Vinyl Dressing
11 1 15
FORM #174.
PAGE 1 OF2
SECTION
1
Identit
Product
Name: (As used on Label)
Product
Number:
Showtime Rubber & Vinyl Dressing #30
#30
Formulated Product
SECTION
2
Hazardous lnoredients/ldentitv lnformation
Hazardous components
OSHA PEL
ACGIH TLV
OTHER LIMIT
Recommended
Nonionic Surfactant
N/A
SECTION 3
Phvsical/Chem ica I Characterist ics
Boiling Point: 212 F
Specific Gravitv: (H2O=1) 1.1
Vapor Pressure: (mm Hg.) 17
Melting Point: N/A
(Air=1)
Vapor Density:
Heavier than air
Slower than butyl acetate
(butyl acetate=1)
Solubility in Water: Complete
White translucent liquid with
SECTION 4
Fire and Explosion Hazard Data
Flash Point: (Method Used) N/A
Flammable Limits: LEL: N/A
Extinguishing Media: N/A
Special Fire Fighting Procedures:
N/A
odor.
UEL:
N/A
5
Reactivitv Data
Stability: Stable
Conditions to Avoid: N/A
lncompatibility: (Materials to Avoid)
SECTION
N/A
Hazardous Decomposition or Bvproducts: N/A
Hazardous Polymerization: Will not occur.
SECTION 6
Health Hazard Data
Primary Routes of Entry: None
lnhalation?
Health Hazards (Acute and Chronic): None known.
Carcinogenicity: No
NPT? IARC Monographs?
9igns and Symptoms of Exposure:
Skin?
lngestion?
OSHA Regulated?
Breathino: Excessive inhalation of vapors can cause nasal and respiratory irritation, dizziness, weakness,
fatigue, nausea, headache, possible unconsciousness, and even asphyxiation.
Eyes: Can cause ssvere irritation, redness, tearing, blurred-vision.
Skin: Prolong'ed or repeated contact can cause moderate irritation, defatting, dermatitis.
Medical Conditions:Gener:ally Aggravated bv Exposure: None known, but any unnecessary exposure to any
chemical should be avoided.
Emergency and First Aid Procedures:
MATERIAL SAFETY DATA SHEET
TO COMPLY WITH OSHA
may be used to comply with
OSHA's Hazard Communication
Standard.
FORM #174.
Showtime Rubber & Vinyl Dressing #30
PAGE2OF 2
SECTION
6
Health Hazard Data
lf Breathed: lf affected, remove individual to fresh air. lf breathing is difficult, administer oxygen. lf
breathing has stopped, give artificial respiration. Keep person warm, quiet and get medical attention.
lf ln Eves: Flush with large amounts of water, lifting upper and lower lids occasionally,. Get medical
attention.
lf On Skin: Thoroughly wash exposed area with soap and water. Remove contaminated clothing. Launder
contaminated clothing before re-use.
lf Swallowed: Give two glasses of water; lnduce vomiting immediately by sticking finger down throat. Call
an. Never
to an unconscious
SECTION 7
Precautions for Safe Handlino and Use
Steps to be taken in case material is released or spilled:
Small Spill: Absorb liquid on paper, vermiculite, floor absorbent, or other absorbent -material and transfer to
hood.
Large Spill: Eliminate all ignition sources (flares, flames including pilot lights, electrical sparks). Persons
not wearing protective equipment should be excluded from area of spill until clean-up has been completed.
Stop spill at source, dike area of spill to prevent spreading. Pump liquid to salvage tank. Remaining liquid
may be taken up on Waste disposal method:
Small Spill: Allow volatile portion to evaporate in hood. Allow sufficient time for vapors to completely clear
hood duct work. Destroy remaining material by burning in an iron pan.
Large Spill: Destroy by Iiquid incineration. Contaminated absorbent may be deposited in a landfill in
accordance with local, state and federal regulation.
Small Spill: Allow volatile portion to evaporate in hood. Allow sufficient time for vapors to completely clear
hood duct work. Destroy remaining material by burning in an iron pan.
Large Spill: Destroy by liquid incineration. Contaminated absorbent may be deposited in a landfill in
accordance with local, state and federal regulation.
Precautions to be taken in Handling and Storing: N/A
Other Precautions: Containers of this material may be hazardous when emptied. Since emptied containers
retain product residues (vapors, liquid, and/or solid), all hazard precautions given in this data sheet must be
observed.
Ventilation:
No special mechanical devices needed.
Protective Gloves: Buna-N
Eve Protection: Chemical splash goggles approved by OSHA.
Work/Hygienic practices: Good practice requires that gross amount of any chemical be removed from the
skin as soon as practical
ially before
SECTION 9
lal Precautions
Theinformationaccumulatedhereinisbelievedtobeaccuratebutisnotwa@ing
with MAGIC BRIGHT CHEMICALS or not. Recipients are advised to confirm in advance of need that the
information is current, applicable, and suitable to their circumstances.